92499 Mercruiser FITTING, EXHAUST MANIFOLD - TOP (45 Degree)


92499 FITTING, EXHAUST MANIFOLD - TOP (45 Degree) Mercruiser 01751347, 01851333, 01854335, 02297343, 02602347, 02608427, 03307332, 03308333, 04544347, 06661346, 30001854, 4052110CR, 443B0002S, 443B1003S, 4454110AS, 473B1F0GS, 474H110AR FITTING
92499 FITTING, EXHAUST MANIFOLD - TOP (45 Degree) Mercruiser
Rating:
33

Buy FITTING, EXHAUST MANIFOLD - TOP (45 Degree) 92499 Mercruiser genuine, new aftermarket parts with delivery
Number on catalog scheme: 12
 

Mercruiser entire parts catalog list:

01751347 1987,1988,1989,1990,1991,1992
01851333 1983,1984
01854335 1985,1986
02297343 1983,1985,1986
02602347 1987,1988,1989,1990,1991,1992,1993,1994,1995
02608427 1987
03307332 1982
03308333 1983,1984,1985,1987
04544347 1987
06661346 1986,1987,1988,1989
30001854 1984,1986
4052110CR 1990,1991,1992
443B0002S 1992,1993
443B1003S 1993,1994,1995
4454110AS 1988,1989,1991,1992
473B1F0GS 1994,1995,1996
474H110AR 1988,1989,1990,1991

Information:


Table 1
J1939 Code and Description CDL Code and Description Comments
970-2
Engine Auxiliary Engine Shutdown Switch : Erratic, Intermittent, or Incorrect 337-2
Remote Emergency Stop Switch : Erratic, Intermittent, or Incorrect The two inputs from the emergency stop switch are in the opposite state.
The code is logged. Note: The air shutoff is optional. Set the programmable parameter with Cat® Electronic Technician (ET) to enable the air shutoff.The 970-31 Engine Auxiliary Engine Shutdown Switch event code will be set when the remote emergency stop switch is activated. This event will prevent engine operation. Electrical power to the Electronic Control Module (ECM) must be removed for 3 seconds to clear this event.
Illustration 1 g06325911
Table 2
Troubleshooting Test Steps Values Results
1. Inspect the Electrical Connectors and the Wiring
A. Turn the main disconnect switch to the OFF position.
B. Verify that the air shutoff mechanisms are set to the OPEN position.
C. Thoroughly inspect the connectors. Refer to Troubleshooting, "Electrical Connectors-Inspect" for additional information.
D. Perform a 45 N (10 lb) pull test on the connector wires.
E. Check the harness for abrasions and pinch points.
Connectors and Wiring
Result: The connectors and wiring appear to be OK.
Proceed to Test Step 2.
Result: There is a problem with the connectors and/or wiring.
Repair: Repair or replace the connectors or wiring. Ensure that all the seals are properly in place and ensure that the connectors are coupled.
If the problem is not resolved, proceed to Test Step 2.
2. Test the Operation of the Control Solenoid for the Air Shutoff Relay and Check for Logged Codes
A. Connect Cat® Electronic Technician (ET) to the service tool connector.
B. Restore the electrical power to the Electronic Control Module (ECM).
C. Test the air shutoff system with the emergency stop switch:
a. Start the engine.
b. Place the emergency stop switch in the STOP position.
c. Check the position of the air shutoff mechanisms. Activation of the emergency stop will activate the air shutoff system and the air shutoff mechanisms will close.
d.


Parts fitting Mercruiser:

29085
 
29085 FITTING, OIL PRESSURE SENDER ADAPTOR
2165203, 2165208, 4231017L1, 4454110JT, 4454118JT, 4542067LS, 4652027LE, 4652027M1, 4652227MW, 473B1F0GS, 474L111JS, 474L118JS, 474L118JT, 4S42028N1, 4S42028TS, 4S42028TT, 4S42028UT, 4S42028UU, 4S420P8UE
52930
 
52930 FITTING, TEE - OIL PRESSURE SENDER
2165203, 2165208, 30001854, 32001876, 37011856, 4111021L1, 4111021TS, 4111021UT, 4111021UU, 411102KN2, 41510P1UE, 430B00001
45084
 
45084 FITTING, HOSE - EXHAUST ELBOW
00014332, 01701335, 02287333, 02297343, 02602347, 02607333, 02608427, 03302336, 03307332, 04544347, 04707333, 04708004, 04881333, 06661346, 07711346, 08986342, 08987343, 228801, 260801, 2888203, 40200002D, 4052110CR, 443B0002S, 443B1003S, 4454110AS,
74036
 
74036 FITTING, GREASE - GIMBAL HOUSING (STAINLESS STEEL)
00014332, 00019003, 01207333, 01321017, 01326013, 01402414, 01407333, 02287333, 02602347, 02607333, 02608427, 08986342, 08987343, 2140208, 2165208, 2250507, 228801, 257B021JS, 260801, 30001854, 37011856, 40280002D, 40420001D, 40420002D, 40430002S, 40
811533
FITTING KIT, Inlet (ALL)
811533 FITTING KIT, Inlet (ALL)
02602347, 02608427, 257B021JS, 4211015L1, 4350100KS, 443B0002S, 443B1003S, 443B100JS, 443HC00JT, 44541101S, 4454110GE, 4454110JT, 45021102S, 457B100KS
814822
FITTING
814822 FITTING
02602347, 02608427, 257B021JS, 4052110CR, 4350104JS, 4350111HS, 4350118JS, 443B0002S, 443B1003S, 443B100JS, 44541101S, 4454110AS, 4454110GE, 4454110JT, 4454118JT, 45021102S, 4502111FE, 457B100KS, 457B101JS, 457B111GS, 457L101JS, 474H110AR, 474L111JS,
806121
FITTING
806121 FITTING
02602347, 02608427, 257B021JS, 40500006T, 40500010T, 40500010U, 40500120U, 4111021L1, 4111021TS, 4111021UT, 4111021UU, 411102KN2, 430L000JS, 4332087N1, 4350100KS, 4350104JS, 4350104KS, 4350111HS, 4350118JS, 4350118KS, 4441027LE, 444106AM1, 444106LPS,
806186
 
806186 FITTING
02602347, 02608427, 257B021JS, 4350104JS, 4350111HS, 4350118JS, 44541101S, 4454110GE, 457B100KS, 457B101JS, 457L101JS
Back to top