09160-22016 Suzuki Thrust Washer


09160-22016 Thrust Washer Suzuki DT50, DT50, DT50ELB, DT50ELC, DT50ELN, DT50ESB, DT50ESC, DT50ESN, DT50M, DT50MLC, DT50MLN, DT50MSC, DT50MSN, DT50W, DT65, DT65, DT65ELC, DT65ELN, DT65ESC, DT65ESN Thrust
09160-22016 Thrust Washer Suzuki
Rating:
33

Buy Thrust Washer 09160-22016 Suzuki genuine, new aftermarket parts with delivery
Number on catalog scheme: 41
 

Suzuki entire parts catalog list:

DT50 1980,1981,1982
DT50 1983
DT50ELB 1977
DT50ELC 1978
DT50ELN 1979
DT50ESB 1977
DT50ESC 1978
DT50ESN 1979
DT50M 1980,1981,1982
DT50MLC 1978
DT50MLN 1979
DT50MSC 1978
DT50MSN 1979
DT50W 1980,1981,1982
DT65 1980,1980,1981,1981,1982,1982
DT65 1980,1980,1981,1981,1982,1982
DT65ELC 1978
DT65ELN 1979
DT65ESC 1978
DT65ESN 1979

Information:


Table 1
Engine Events
J1939 Code and Description Conditions which Activate the Code System
Response
5686-17 Engine Exhaust Gas Port 1 Difference from Average Temperature:Low-least severe (1)
5687-17 Engine Exhaust Gas Port 2 Difference from Average Temperature:Low-least severe (1)
5688-17 Engine Exhaust Gas Port 3 Difference from Average Temperature:Low-least severe (1)
5689-17 Engine Exhaust Gas Port 4 Difference from Average Temperature:Low-least severe (1)
5690-17 Engine Exhaust Gas Port 5 Difference from Average Temperature:Low-least severe (1)
5691-17 Engine Exhaust Gas Port 6 Difference from Average Temperature:Low-least severe (1)
5692-17 Engine Exhaust Gas Port 7 Difference from Average Temperature:Low-least severe (1)
5693-17 Engine Exhaust Gas Port 8 Difference from Average Temperature:Low-least severe (1)
5694-17 Engine Exhaust Gas Port 9 Difference from Average Temperature:Low-least severe (1)
5695-17 Engine Exhaust Gas Port 10 Difference from Average Temperature:Low-least severe (1)
5696-17 Engine Exhaust Gas Port 11 Difference from Average Temperature:Low-least severe (1)
5697-17 Engine Exhaust Gas Port 12 Difference from Average Temperature:Low-least severe (1) The cylinder exhaust temperature is lower than the average temperature for all of the cylinders. The amount of deviation has exceeded the trip point for the programmed delay time. The code is logged.
The alarm output is activated.
Table 2
Engine Events
J1939 Code and Description Conditions which Activate the Code System
Response
5686-15 Engine Exhaust Gas Port 1 Difference from Average Temperature:High-least severe (1)
5687-1 Engine Exhaust Gas Port 2 Difference from Average Temperature:Low-most severe (3)
5688-1 Engine Exhaust Gas Port 3 Difference from Average Temperature:Low-most severe (3)
5689-1 Engine Exhaust Gas Port 4 Difference from Average Temperature:Low-most severe (3)
5690-1 Engine Exhaust Gas Port 5 Difference from Average Temperature:Low-most severe (3)
5691-1 Engine Exhaust Gas Port 6 Difference from Average Temperature:Low-most severe (3)
5692-1 Engine Exhaust Gas Port 7 Difference from Average Temperature:Low-most severe (3)
5693-1 Engine Exhaust Gas Port 8 Difference from Average Temperature:Low-most severe (3)
5694-1 Engine Exhaust Gas Port 9 Difference from Average Temperature:Low-most severe (3)
5695-1 Engine Exhaust Gas Port 10 Difference from Average Temperature:Low-most severe (3)
5696-1 Engine Exhaust Gas Port 11 Difference from Average Temperature:Low-most severe (3)
5697-1 Engine Exhaust Gas Port 12 Difference from Average Temperature:Low-most severe (3) The cylinder exhaust temperature is lower than the average temperature for all of the cylinders. The amount of deviation has exceeded the trip point for the programmed delay time. The code is logged.
The shutdown output is activated.
The engine is shut down. Probable Causes
Software for the Engine Temperature Module (ETM)
Monitoring system parameters
Inlet air restriction
Operation with a light load
Faulty thermocouple
Insufficient ignition
Valve lash settings
Low cylinder compressionRecommended Actions
Software for the ETM and Parameter Settings
Ensure that the latest version of software for the ETM has been installed in the control module.Monitoring System Parameters
Ensure that the monitoring system parameters for the exhaust port temperatures are set correctly. Refer to Systems Operation, "Engine Monitoring Parameters" for information that relates to the default parameters, ranges, and delay times of the monitoring system parameters that are for the exhaust port temperatures.Inlet Air Restriction
Inlet air restriction can cause uneven exhaust port temperatures. For example, the cylinders at the front half of the engine may have exhaust port temperatures that are 10 to 20 °C (18 to 36 °F) higher than the exhaust port temperatures that are for the cylinders at the rear half of the engine. If this condition occurs, measure the inlet air restriction of the turbocharger. Make repairs in order to optimize the inlet air delivery from the turbocharger.Ensure that the spark arrestors for each cylinder have not become restricted. Replace any spark arrestors that are damaged or obstructed. Operation with a Light Load
Operation with a low load can result in low exhaust temperatures. Operate the engine at low idle or near low idle in order to identify a misfire problem.Troubleshoot the cause of the misfire. Refer to Troubleshooting, "Engine Misfires, Runs Rough or Is Unstable".Faulty Thermocouples
Observe the temperatures from the thermocouples after the engine is shut off. If the engine is allowed to cool to ambient conditions, the thermocouples will report a temperature that is close to the ambient temperature.When the engine is operating properly, the temperatures from similar locations are reduced at a similar rate. Also, the temperatures from similar locations are comparable.If any discrepancies are found, switch the suspect thermocouple for another thermocouple. If the temperature problem follows the thermocouple, replace the suspect thermocouple.If the temperature problem stays at the original location of the suspect thermocouple, investigate the cause for the low temperature.Insufficient Ignition
Use Cat ET to check for logged diagnostic codes that relate to the ignition system. Troubleshoot the code. Refer to Troubleshooting, "Ignition Primary - Test".If no logged diagnostic codes are present for the suspect cylinder, inspect the components of the ignition system for the cylinder. Check the following components for problems:
Engine wiring
Ignition transformers
Spark plugsRefer to Troubleshooting, "Ignition Secondary - Test".Valve Lash Settings
Check the valve lash settings for the valves on the engine. Refer to Testing and Adjusting, "Engine Valve Lash - Inspect/Adjust" for information that is related to adjusting the valve lash for the engine.Low Cylinder Compression
Measure the cylinder pressures of the suspect cylinders in order to check for problems that are related to compression.If low cylinder compression is found, investigate the cause of the low compression. Perform the necessary repairs.Refer to Testing and Adjusting, "Compression - Test" for information that is related to adjusting the valve lash for the engine.


Parts thrust Suzuki:

31361-95240
 
31361-95240 Thrust Washer Kit
20ELB, 20ELC, 20ELN, 25ELB, 25ELC, 25ELN, DT20ESB, DT20ESC, DT20ESN, DT20MLB, DT20MLC, DT20MLN, DT20MSB, DT20MSC, DT20MSN, DT25ESB, DT25ESC, DT25ESN, DT25MLB, DT25MLC, DT25MLN, DT25MSB, DT25MSC, DT25MSN, DT50, DT50, DT50M, DT50W, DT65, DT65
08211-30422
 
08211-30422 Thrust Washer
DT35CRLH, DT35CRLJ, DT35CRLK, DT35CRSH, DT35CRSJ, DT35CRSK, DT35MCLH, DT35MCLJ, DT35MCLK, DT35MCSH, DT35MCSJ, DT35MCSK, DT35TCLH, DT35TCLJ, DT35TCLK, DT50ECLE, DT50ELB, DT50ELC, DT50ELN, DT50ESB, DT50ESC, DT50ESN, DT50MCLE, DT50MLC, DT50MLN, DT50MSC,
08211-30401
 
08211-30401 Thrust Washer
30ELE, 30ESE, 30MLE, DT20ELG, DT20ELH, DT20ELJ, DT20ESG, DT20ESH, DT20ESJ, DT20MLG, DT20MLH, DT20MLJ, DT20MSG, DT20MSH, DT20MSJ, DT25ELF, DT25ELG, DT25ELH, DT25ELJ, DT25ESG, DT25ESH, DT25ESJ, DT25MLD, DT25MLE, DT25MLF, DT25MLG, DT25MLH, DT25MLJ, DT25
09166-17003
 
09166-17003 Thrust Washer
DT50ELB, DT50ELC, DT50ELN, DT50ESB, DT50ESC, DT50ESN, DT50MLC, DT50MLN, DT50MSC, DT50MSN, DT65ELC, DT65ELN, DT65ESC, DT65ESN
09166-17004
 
09166-17004 Thrust Washer
DT50, DT50, DT50ELB, DT50ELC, DT50ELN, DT50ESB, DT50ESC, DT50ESN, DT50M, DT50MLC, DT50MLN, DT50MSC, DT50MSN, DT50W, DT55CLF, DT55CRLG, DT55CRLJ, DT55CRLK, DT55CRLL, DT55CRSG, DT55CRSH, DT55HTCLH, DT55HTCLJ, DT55HTCLK, DT55HTCLL, DT55TCLG, DT55TCLH, D
08211-17303
 
08211-17303 Thrust Washer
DT50ELB, DT50ELC, DT50ELN, DT50ESB, DT50ESC, DT50ESN, DT50MLC, DT50MLN, DT50MSC, DT50MSN, DT65ELC, DT65ELN, DT65ESC, DT65ESN
57100-95860
 
57100-95860 THRUST WASHER
DT50, DT50M, DT50W, DT65, DT65
09160-22024
 
09160-22024 THRUST WASHER (T:1.75)
DT50, DT50, DT50M, DT50W, DT65, DT65
Back to top